MOT performance
Toyota Hi-Ace MOT pass rate and common failures
Across 30,426 MOT tests of the Toyota Hi-Ace in 2023–2024, 64.5% passed first time. Allowing for age, mileage and fuel, Toyota Hi-Aces failed 16% less often than comparable cars. The most common failure item was “position lamp: not working”, on 5.70% of tests.
30,426 MOT tests on 16,225 vehicles, 2023–2024 · Source: DVSA (Open Government Licence) · Analysis: 73 Auto
Check a specific car's MOT history and running costsAt a glance
| Figure | Value | Basis |
|---|---|---|
| First-time pass rate | 64.5% | ±0.5 pts (95%), n = 30,426 |
| Failures vs similar cars | 0.84× | same age, mileage and fuel = 1.00 |
| Tests with a dangerous defect | 7.4% | n = 30,426 |
| Average age at test | 17.5 years | n = 30,426 |
| Median mileage at test | 140,084 miles | n = 30,426 |
| Vehicles tested | 16,225 | 2023–2024 |
Where Toyota Hi-Aces fail
The share of MOT tests that failed on each area, and how that compares with cars of the same age, mileage and fuel. Areas where the difference is large and clear link to their own page.
| Area | Tests failed on it | vs similar cars |
|---|---|---|
| Lights, reflectors and electrical | 16.9% | -18% |
| Suspension | 13.1% | -26% |
| Brakes | 9.3% | -33% |
| Driver's view of the road | 7.8% | +11% |
| Body, chassis and structure | 6.9% | -29% |
| Noise, emissions and leaks | 4.5% | -9% |
| Tyres | 3.9% | -44% |
| Seat belts and airbags | 1.9% | -36% |
| Steering | 0.8% | -84% |
| Registration plates and VIN | 0.7% | +5% |
| Road wheels | 0.2% | -60% |
| Speedometer and driving controls | 0.0% | -5% |
Most common failure items
| Item | Area | Share of tests |
|---|---|---|
| Position lamp: not working | Lights, reflectors and electrical | 5.70% |
| Component mounting prescribed areas: prescribed area excessively corroded significantly reducing structural strength | Suspension | 5.56% |
| Wipers: does not clear the windscreen effectively | Driver's view of the road | 4.47% |
| Stop lamp: not working | Lights, reflectors and electrical | 4.01% |
| Rigid brake pipes: excessively corroded | Brakes | 3.16% |
| Linkage pins and bushes: pin or bush excessively worn | Suspension | 2.38% |
| Washers: provides insufficient washer liquid | Driver's view of the road | 1.98% |
| Registration plate lamp(s): inoperative in the case of a single lamp or all lamps | Lights, reflectors and electrical | 1.98% |
| Integral vehicle structure condition: corroded to the extent that the rigidity of the assembly is significantly reduced | Body, chassis and structure | 1.79% |
| Rear fog lamp: not working | Lights, reflectors and electrical | 1.74% |
Most common advisories
Advisories are items the tester expects to need attention soon; they don't fail the test.
| Item | Area | Share of tests |
|---|---|---|
| Rigid brake pipes: excessively corroded | Brakes | 18.13% |
| Tread depth: tread depth below requirements of 1.6mm | Tyres | 12.96% |
| Coil spring: corroded so that its cross sectional area is reduced and seriously weakened | Suspension | 8.52% |
| Wheel bearings: has excessive play | Suspension | 8.41% |
| Linkage pins and bushes: pin or bush excessively worn | Suspension | 8.06% |
Pass rate by age
| Age at test (years) | Tests | First-time pass rate | Failures vs similar cars |
|---|---|---|---|
| 7-8 | 359 | 71.9% | -7% |
| 9-10 | 361 | 68.4% | -11% |
| 11-12 | 1,625 | 68.4% | -17% |
| 13-15 | 7,019 | 67.0% | -21% |
| 16+ | 20,801 | 63.1% | -15% |
Pass rate by registration year
| Registered | Tests | First-time pass rate | Failures vs similar cars |
|---|---|---|---|
| 2011 | 1,116 | 67.5% | 0.84× |
| 2010 | 1,827 | 66.7% | 0.81× |
| 2009 | 1,919 | 68.6% | 0.75× |
| 2008 | 3,453 | 66.5% | 0.78× |
| 2007 | 3,843 | 65.8% | 0.79× |
| 2006 | 3,060 | 64.5% | 0.80× |
| 2005 | 2,586 | 64.5% | 0.79× |
| 2004 | 2,296 | 61.5% | 0.86× |
| 2003 | 1,999 | 61.5% | 0.86× |
| 2002 | 1,613 | 62.9% | 0.85× |
| 2001 | 1,463 | 60.6% | 0.92× |
| 2000 | 1,221 | 57.4% | 1.02× |
| 1999 | 829 | 62.6% | 0.94× |
| 1998 | 777 | 60.5% | 1.01× |
| 1997 | 460 | 62.2% | 0.98× |
Years with fewer tests are shown for completeness; only years with enough tests have their own page.
Check a specific Toyota Hi-Ace
Enter a UK registration to see that car's own MOT history and what it is likely to cost to own. Your first check is free and shows the vehicle summary and its headline ownership cost. The category-by-category breakdown is part of a paid check.
UK number plate or 17-character VIN
About this data. These are MOT test results, not a measure of mechanical reliability: a car's MOT outcome reflects its condition on the day, which depends on how it has been maintained and driven as well as how it was built. Figures cover class 4 vehicles (cars and light vans), normal tests only (retests excluded), outcomes pass, fail and pass after rectification at the station; vehicles at least 2.5 years old at test. Tests from 2023-01-01 to 2024-12-30. “Compared with similar cars” means compared with the national rate for cars of the same age, mileage band and fuel. Contains public sector information licensed under the Open Government Licence v3.0. Makes and models are matched to 73 Auto's vehicle catalogue; tests that can't be matched are left out rather than guessed. See how the MOT figures are produced.